收稿日期: 2013-08-30
修回日期: 2013-11-04
网络出版日期: 2014-05-10
基金资助
国家自然科学基金项目(编号:41272339)资助.
Mechanism of Water-fracturing-induced Permeability Increment of “Three-Soft” Coal Seam and Construction Parameters Determination
Received date: 2013-08-30
Revised date: 2013-11-04
Online published: 2014-05-10
针对豫西“三软”煤矿区瓦斯低渗难抽问题的特殊性，探讨了主采二1煤层生、储气层的变形特征。以ABAQUS软件为平台，依托告成煤矿建立了滑动构造带三维非线性流—固耦合水力压裂模型。应用多参数耦合模拟方法，探讨了定向注水压裂过程中目标层的流变—损伤—渗流耦合行为;同时利用T—P损伤演化准则的Cohesive单元，模拟了目标层裂隙的起裂和扩展过程。此外，探讨了煤岩体对动力荷载的响应机制和动态条件下的压裂效果。研究结果表明，定向注水新工艺条件下，当注水压力为4.5MPa，注水时间在2h左右时，水力压裂在顺层软煤中的影响半径基本可以达到80～100m这一理想数据，从而大幅度地改善了“三软”煤层低渗性能。实践证明，采用正确的施工方法和技术参数优化组合，可以有效提高煤层的透气性和瓦斯抽采效果，对复杂矿区瓦斯综合利用具有重要借鉴意义。
王志荣,韩中阳，李树凯，胡向志 . “三软”煤层注水压裂增透机理及瓦斯抽采施工参数确定[J]. 天然气地球科学, 2014 , 25(5) : 739 -746 . DOI: 10.11764/j.issn.1672-1926.2014.05.739
In view of the low permeability and difficult extraction of gas in “three soft” coal seam in western Henan,China,this paper studied the deformation characteristics of gas generation and storage layers in Ⅲ coal seam.Based on ABAQUS platform and Gaocheng coal mine,a three-dimensional nonlinear fluid-solid coupling hydraulic fracturing model was established.Then,the rheology-damage-seepage coupling behavior of target layer was described by multi-parameter coupling simulation method,and the initiation and propagation of crack was simulated by cohesive element of T-P damage evolution criterion.In addition,the response mechanism of rock mass against dynamic load and the fracturing effect under dynamic condition were discussed.The results show that when the injection pressure is 4.5MPa,and injection time in about 2 hours,the influence radius of hydraulic fracturing in bedding coal seam can basically reach an ideal data of 80-100m and it greatly improves the low permeability of “three soft” coal seam.Practice also proves that correct construction method and optimal combination of technical parameters can effectively improve the permeability and gas extraction of coal seam,which has important significance to comprehensive utilization of gas in complex mining area.
Key words： Three soft; coal seam; Hydraulic fracturing; Fluid-solid coupling; Gas extraction
［1］Wang Zhirong,Chen Lingxia,Cheng Congren,et al.Forecast of gas geological hazards for “three-soft” coal seams in gliding structural areas[J].Journal of China University of Mining & Technology,2007,17(4):484-488.
［2］Wang Zhirong,Lang Dongsheng,Liu Shijun,et al.Tectonic control on gas geological hazard in Ludian gliding structure in West Henan[J].Journal of China Coal Society,2006,31(5):553-557.［王志荣,郎东升,刘士军,等.豫西芦店滑动构造区瓦斯地质灾害的构造控制作用[J].煤炭学报,2006,31(5):553-557.］
［3］Ren Qingwen,Dong Yuwen,Yu Tiantang.Numerical modeling of concrete hydraulic fracturing with extended finite element method[J].China Science:Technical Sciences,2009,52(3):559-565.
［4］Wang Junjie,Zhang Huiping,Zhao Mingjie,et al.Mechanisms of hydraulic fracturing in cohesive soil[J].Water Science and Engineering,2009,2(4):95-102.
［5］Meyer B R,Bazan L W.A Discrete Fracture Network Model for Hydraulically Induced Fractures Theory［C］.SPE Hydraulic Fracturing Technology Conference,2011:216-225.
［6］Adachi J,Siebrits E,Peirce A.Computer simulation of hydraulic fractures[J].International Journal of Rock Mechanics and Mining Sciences,2007,44:739-757.
［7］Sommerton W J,Soylemezoglu I M,Dudley R C.Effect of stress on permeability of coal[J].International Journal of Rock Mechanics and Mining Sciences & Geomechanics Abstracts,1975,12(6):129-145.
［8］Tang Jupeng,Pan Yishan,Li Chengquan,et al.Experimental study of desorption and seepage of coalbed methane under solid-fluid coupling[J].Journal of China University of Mining & Technology,2006,35(2):274-278.［唐巨鹏,潘一山,李成全,等.固流耦合作用下煤层气解吸—渗流实验研究[J].中国矿业大学学报,2006,35(2):274-278.］
［9］Tang Jupeng,Pan Yishan,Li Chengquan,et al.Experimental study on effect of effective stress on desorption and seepage of coalbed methane[J].Chinese Journal of Rock Mechanics and Engineering,2006,25(8):1563-1568.［唐巨鹏,潘一山,李成全,等.有效应力对煤层气解吸渗流影响试验研究[J].岩石力学与工程学报,2006,25(8):1563-1568.］
［10］Xie Weiyang,Li Xiaoping.Steady productivity of horizontal well in hydraulic fracture induced shale gas reservoir[J].Natural Gas Geoscience,2012,23(2):387-392.［谢维扬,李晓平.水力压裂缝导流的页岩气藏水平井稳产能力研究[J].天然气地球科学,2012,23(2):387-392.］
［11］Wang Hanxiang,Lan Wenjian,Liu Yanxin,et al.Mathematical model of fluid-solid coupling percolation with coal powder in coal reservoir[J].Natural Gas Geoscience,2013,24(4):667-670.［王旱祥,兰文剑,刘延鑫,等.煤储层含煤粉流体流固耦合渗流数学模型[J].天然气地球科学,2013,24(4):667-670.］
［12］Yin Guangzhi,Li Xiaoquan,Zhao Hongbao,et al.Experimental research on effect of geostress on outburst coal′s seepage[J].Chinese Journal of Rock Mechanics and Engineering,2008,27(12):2557-2561.［尹光志,李晓泉,赵洪宝,等.地应力对突出煤瓦斯渗流影响试验研究[J].岩石力学与工程学报,2008,27(12):2557-2561.］
［13］Hu Guozhong,Wang Hongtu,Fan Xiaogang,et al.Investigation on law of methane gas flow in coal with coal-gas outburst hazard and low permeability[J].Chinese Journal of Rock Mechanics and Engineering,2009,28(12):2527-2534.［胡国忠,王宏图,范晓刚,等.低渗透突出煤的瓦斯渗流规律研究[J].岩石力学与工程学报,2009,28(12):2527-2534.］
［14］Wang Zhirong,Li Shukai,Wang Yuanxiao.Characteristics of compression fracture of “three soft” coal bed by perfusion and gas sucking technique[J].Journal of Coal Science and Engineering,2011,17(1):43-46.
［15］Lomizc G M.Flow in Fractured Rock(in Russian)［M］.Moscow:Gosemergoizdat,1951:127-129.
［16］Romm E S.Flow in Fractured Rock(in Russian)［M］.Moscow:Nedra Publishing House,1966:67-65.
［17］Louis C.A Study of Ground Water Flow in Jointed Rock and Its Influence on the Stability of Rock Masses［R］.London:Imperial College,1969.
［18］Biot M A.General theory of three-dimensional consolidation[J].Journal of Applied Physics,1941,12(2):155-164.
［19］Duan Xiaoning,Li Jianchu,Liu Jishan.Numerical simulation of flow in fractured rocky masses with interaction of seepage and stress-strain[J].Journal of Dalian University of Technology,1992,32(6):712-717.［段小宁,李鉴初,刘继山.应力场与渗流场相互作用下裂隙岩体水流运动的数值模拟[J].大连理工大学学报,1992,32(6):712-717.］
［20］Yang Tianhong.Research on Seepage Property and Stress Coupling in Rock Failure Process［D］.Shenyang:Northeastern University,2001:20-40.［杨天鸿.岩石破裂过程渗透性质及其应力耦合作用研究［D］.沈阳:东北大学,2001:20-40.］
［21］Leo C J,Booker J R.A time-stepping FEM for analysis of contaminant transport in fractured porous media[J].International Journal for Numerical and Analytical Methods in Geomechanics,1996,20(12):847-864.
［22］Tang Chun′an,Wang Shuhong,Fu Yufang.Numerical Experiments of Rock Failure Process［M］.Beijing:Science Press,2003:35-50.［唐春安,王述红,傅宇方.岩石破裂过程数值试验［M］.北京:科学出版社,2003:35-50.］
［23］Wu Yanqing.Principles of rock mass hydraulics(3)-concentrated parameter model and continuum model of rock mass coupling fields of flow and stress[J].Hydrogeology and Engineering Geology,1997,24(2):54-57.［仵彦卿.岩体水力学基础(三)——岩体渗流场与应力场耦合的集中参数模型及连续介质模型[J].水文地质工程地质,1997,24(2):54-57.］
/
| 〈 |
|
〉 |
甘公网安备 62010202000678号